FLHR WINDSHIELD KITS
J007182022-04-28
GENERAL
Kit Number
57981-97, 57994-94, 57994-94A, 57995-96, 57995-96A, 57767-00, 58163-02, 58731-02, 58796-02, 57807-04, 57668-10, 57400380, 57400381, 57400383
Models
For model fitment information, see the P&A retail catalog or the Parts and Accessories section of www.harley-davidson.com (English only).
Table 1. Models
Kits | Contents |
|---|---|
57981-97 | Low profile smoked windshield |
57767-00 | Low profile clear windshield |
57994-94 | Standard height clear windshield |
57994-94A | Standard height clear windshield |
57995-96 | Tall clear windshield |
57995-96A | Tall clear windshield |
58163-02 | Road King wind deflector, dark, smoked |
58731-02 | Road King wind deflector, clear, international |
58796-02 | Road King wind deflector, dark smoked, 3 inches oversized |
57807-04 | Standard height clear windshield with flames |
57668-10 | Windshield, China |
57400380 | 20" clear windshield with black braces |
57400381 | 18" clear windshield with black braces |
57400383 | 16" light tint windshield with black braces |
NOTICE
Do not use windshield bags with flamed windshields. Damage to graphics will occur. (00393f)
INSTALLATION
- Lower the windshield into position by carefully inserting the side brackets between the headlamp housing and the passing lamp supports until the bottom notches are seated on the lower grommets. Be sure that the notches on each bracket are firmly seated on a rubber grommet.
- Standing at the front of the motorcycle, gently push the top of the windshield toward the rear until the upper notches fully engage the upper grommets.
- Push down on the wireform latch springs so that they overhang the rubber grommets. If some adjustment is necessary, loosen the retaining bolts and rotate the latch springs into the proper position.
WARNINGImproper installation of accessories or loading of cargo can affect motorcycle stability and handling, which could result in death or serious injury. (00455b)
WARNINGFailure to provide adequate clearance between stationary and moving parts can cause loss of control, which could result in death or serious injury. (00378a)
NOTE
Inspect windshield upon completion of installation. Be sure windshield mounting does not restrict full left or full right movement of front fork assembly. If restriction does occur, adjust windshield as needed until proper clearance is obtained. Have experienced Harley-Davidson service personnel correct any problems before riding with this accessory installed.
NOTE
Check mounting hardware periodically. Never ride with loose mounts. A loose mounting causes extra stress on all other mounts, as well as the windshield itself, and could result in premature failure of components.
CARE AND CLEANING
NOTE
Sunlight reflections off of the inside curvature of a windshield can, at certain times of the day, cause extreme heat build-up on motorcycle instruments. Exercise care in parking. Park facing the sun, place an opaque object over the instruments, or adjust the windshield to avoid reflections.
NOTICE
Polycarbonate windshields/wind deflectors require proper attention and care to maintain. Failure to maintain polycarbonate properly can result in damage to the windshield/wind deflector. (00483e)
NOTICE
Use only Harley-Davidson recommended products on Harley-Davidson windshields. Do not use harsh chemicals or rain sheeting products, which can cause windshield surface damage, such as dulling or hazing. (00231c)
Do not clean polycarbonate in hot sun or high temperature. Powdered, abrasive or alkaline cleanser will damage the windshield. Never scrape the windshield with a razor blade or other sharp instruments because permanent damage will result.
NOTE
Covering the windshield with a clean, wet cloth for about 15 minutes before washing will make dried bug removal easier.
Harley-Davidson Windshield Water Repellent Treatment Part Number 99841-01 is approved for use on Harley-Davidson polycarbonate windshields.
SERVICE PARTS
NOTE
Typical windshield shown. Actual windshield may vary
Figure 1. Service Parts: Service Parts: Wind Deflector
Table 2. Service Parts: Wind Deflector
Kits 57981-97, 57994-94, 57994-94A, 57995-96, 57995-96A, 57767-00, 57807-04, 57668-10 | ||||||
|---|---|---|---|---|---|---|
Item | Description (Quantity) | Part Number | Item | Description (Quantity) | Part Number | |
1 | Windshield, clear, 2 inches oversize | 58433-96 | 7 | Inner horizontal brace | 58431-94 | |
Windshield, clear, standard | 58193-94 | 8 | Right bracket | 58084-94 | ||
Windshield, clear, 4 inches undersized | 57768-00 | 9 | Left bracket | 58088-94 | ||
Windshield, smoked, 4 inches undersized | 58195-94 | 10 | Spring latches (2) | 38722-94 | ||
Windshield, clear with flames | 57809-04 | 11 | Panhead Torx screws (2) | 2452 | ||
Windshield, China | 57400005 | 12 | Panhead Torx screws (11) | 2921A | ||
2 | Outer, right, vertical brace | 58406-75A | 13 | Plain washers (8) | 6119 | |
3 | Outer, left, vertical brace | 58408-75A | 14 | Acorn nuts (13) | 7651 | |
4 | Outer vertical brace tape (2) | 58417-77 | Reference items: | |||
5 | Outer horizontal brace | 58428-94 | A | Rubber grommet | ||
6 | Horizontal brace tape (2) | 58416-77A | ||||
Figure 2. Service Parts: Wind Deflector
Table 3. Service Parts: Wind Deflector
Kits 58163-02, 58731-02, 58796-02 | ||||||
|---|---|---|---|---|---|---|
Item | Description (Quantity) | Part Number | Item | Description (Quantity) | Part Number | |
1 | Wind deflector, smoked | 58906-02 | 8 | Right bracket | 58542-02 | |
Wind deflector, clear, international | 58908-02 | 9 | Left bracket | 58543-02 | ||
Wind deflector, smoked, 3 inch oversized | 58799-02 | 10 | Spring latches (2) | 38722-94 | ||
2 | Outer, right, vertical brace | 58674-02 | 11 | Panhead Torx screws (2) | 2452 | |
3 | Outer, left, vertical brace | 58677-02 | 12 | Panhead Torx screws (11) | 2921A | |
4 | Outer vertical brace tape (2) | 58664-02 | 13 | Plain washers (8) | 6119 | |
5 | Outer horizontal brace | 58476-02 | 14 | Acorn nuts (13) | 7651 | |
6 | Horizontal brace tape (2) | 58573-02 | Reference items: | |||
7 | Inner horizontal brace | 58462-02 | A | Rubber grommet | ||
Figure 3. Service Parts: Wind Deflector
Table 4. Service Parts: Wind Deflector
Kits 57400380, 57400381, 57400383 | ||||||
|---|---|---|---|---|---|---|
Item | Description (Quantity) | Part Number | Item | Description (Quantity) | Part Number | |
1 | Wind deflector, clear, 20 inch | 58193-94 | 8 | Right bracket, black | 57300188 | |
Wind deflector, clear, 18 inch | 58327-06 | 9 | Left bracket, black | 57300190 | ||
Wind deflector, lt smk, 16 inch | 58195-94 | 10 | Spring latches (2) | 38722-94 | ||
2 | Outer, right, vertical brace, black | 57300187 | 11 | Panhead Torx screws (2) | 2452 | |
3 | Outer, left, vertical brace, black | 57300189 | 12 | Panhead Torx screws (11) | 2921A | |
4 | Outer vertical brace tape (2) | Not Sold Separately | 13 | Plain washers (8) | 6119 | |
5 | Outer horizontal brace, black | 57300191 | 14 | Acorn nuts (13) | 7651 | |
6 | Horizontal brace tape (2) | Not Sold Separately | Reference items: | |||
7 | Inner horizontal brace, black | 57300192 | A | Mounting Hardware Kit | 58221-04 | |