TOURING REPLACEMENT WINDSHIELD KITS
J006722005-12-08
GENERAL
Kit Number
58442-96, 58571-06, 57024-06 and 57026-06
Models
The following Touring Replacement Windshield Kits install on accessory windshield kits, Harley-Davidson Part No. 58570-96 and 58441- 96.
Table 1. Models
Kits | Contents |
|---|---|
57024-06 | Clear windshield |
57026-06 | Smoked windshield |
58571-96 | Clear windshield |
58442-96 | Smoked windshield |
INSTALLATION
| 1. | Remove stock windshield. | |
| 2. | Remove all hardware that secures mounting brackets to windshield. The nine screws must be removed with a T-27 TORX® screwdriver. Save all hardware and brackets for installing new windshield. | |
| 3. | Remove all old tape from brackets and apply new tape (2 and 3) from kit onto brackets. Align holes in tape with holes in brackets. | |
| 4. | Install rubber washers (4) between inner vertical braces and windshield. NOTE Do not over-tighten fasteners. Over-tightening can crack the windshield. | |
| 5. | Install all windshield brackets. Tighten all screws and acorn nuts to 5.4–6.8 N·m (48–60 in-lbs). | |
| 6. | Install windshield on motorcycle. | |
| 7. | Refer to the Owner's Manual for information on windshield care. |
WARNINGImproper installation of accessories or loading of cargo can affect motorcycle stability and handling, which could result in death or serious injury. (00455b)
WARNINGFailure to provide adequate clearance between stationary and moving parts can cause loss of control, which could result in death or serious injury. (00378a)
NOTE
Inspect windshield upon completion of installation. Be sure windshield mounting does not restrict full left or full right movement of front fork assembly. Restricted movement could affect handling, resulting in death or serious injury. If restriction does occur, adjust windshield as needed until proper clearance is obtained. Have experienced Harley-Davidson service personnel correct any problems before riding with this accessory installed.
NOTE
Check mounting hardware periodically. Never ride with loose mounts. A loose mounting causes extra stress on all other mounts, as well as the windshield itself, and could result in premature failure of components.
CARE AND CLEANING
NOTE
Sunlight reflections off of the inside curvature of a windshield can, at certain times of the day, cause extreme heat build-up on motorcycle instruments. Exercise care in parking. Park facing the sun, place an opaque object over the instruments, or adjust the windshield to avoid reflections.
NOTICE
Harley-Davidson windshields are made of Lexan. Lexan is a more durable and distortion-resistant material than other types of motorcycle windshield material, but still requires attention and care to maintain. Failure to maintain Lexan properly can result in damage to the windshield. (00230b)
NOTICE
Use only Harley-Davidson recommended products on Harley-Davidson windshields. Do not use harsh chemicals or rain sheeting products, which can cause windshield surface damage, such as dulling or hazing. (00231c)
NOTICE
Do not use benzine, paint thinner, gasoline or any other type of harsh cleaner on the windshield. Doing so will damage the windshield surface. (00232c)
Do not clean Lexan® polycarbonate in hot sun or high temperature. Powdered, abrasive or alkaline cleanser will damage the windshield. Never scrape the windshield with a razor blade or other sharp instruments because permanent damage will result.
NOTE
Covering the windshield with a clean, wet cloth for about 15 minutes before washing will make dried bug removal easier.
Harley-Davidson Windshield Water Repellent Treatment Part Number 99841-01 is approved for use on Harley-Davidson Lexan® windshields.
SERVICE PARTS
Figure 1. Service Parts: Touring Replacement Windshield Kits
Table 2. Service Parts: Touring Replacement Windshield Kits
Kits 58442-96 and 58571-96 | Kits 57024-06 and 57026-06 | |||||
|---|---|---|---|---|---|---|
Item | Description (Quantity) | Part Number | Item | Description (Quantity) | Part Number | |
1 | Windshield (smoked) | Not Sold Separately | 1 | Windshield, Touring FXD (smoked) | Not Sold Separately | |
Windshield (clear) | Not Sold Separately | Windshield, Touring FXD (clear) | Not Sold Separately | |||
2 | Horizontal tape for braces (2) | 58582-96 | 2 | Horizontal tape for braces (2) | 58582-96 | |
3 | Vertical tape for braces (2) | 58583-96 | 3 | Vertical tape for braces (2) | 57019-06 | |
4 | Rubber washers (6) | 58152-96 | 4 | Washer, rubber (4) | 58152-96 | |