SCREAMIN EAGLE ADJUSTABLE ROCKER ARM KITS
J064782016-12-15
GENERAL
Kit Numbers
17300069, 17300070
Models
For model fitment information, see the Screamin' Eagle Performance Parts and Accessories catalog, the Parts and Accessories section of www.harley-davidson.com (English only), or visit www.h-d.com/racecatalog.
Installation Requirements
WARNINGRider and passenger safety depend upon the correct installation of this kit. Use the appropriate service manual procedures. If the procedure is not within your capabilities or you do not have the correct tools, have a Harley-Davidson dealer perform the installation. Improper installation of this kit could result in death or serious injury. (00333b)
NOTE
This instruction sheet references service manual information. A service manual for this year/model motorcycle is required for this installation. One is available from a Harley-Davidson dealer.
PREPARATION
WARNINGTo prevent accidental vehicle start-up, which could cause death or serious injury, remove main fuse before proceeding. (00251b)
| 1. | See the service manual. Remove the following components: a. Seat b. Fuel tank c. Cooling lines d. Upper rocker cover |
REMOVAL
| 1. | Remove the rocker arms. See the service manual. |
INSTALLATION
| 1. | Set piston at approximate BDC on the power stroke. | |
| 2. | Install new rocker arms per the service manual. |
ADJUST VALVE LASH
| 1. | See Figure 1. Loosen lash adjuster nut (2). | |
| 2. | While holding fixed arm (3) against valve, rotate lash adjuster screw (1) until clearance is removed. | |
| 3. | Hold lash adjuster screw. Tighten lash adjuster nut. Torque: 10.2–13.6 N·m (90–120 in-lbs) | |
| 4. | Repeat with remaining rocker arm. |
| 1 | Lash adjuster screw |
| 2 | Lash adjuster nut |
| 3 | Fixed arm |
Figure 1. Adjust Valve Lash
COMPLETION
| 1. | See the service manual. Install the following components: a. Upper rocker cover b. Cooling lines c. Fuel tank d. Seat | |
| 2. | After installing seat, pull up on the seat to verify that it is secure. | |
| 3. | NOTE Verify that the ignition is off before installing the main fuse. |
SERVICE PARTS
Figure 2. Service Parts: Screamin' Eagle Adjustable Rocker Arm Kits
Table 1. Service Parts
Item | Description (Quantity) | Part Number |
|---|---|---|
1 | Adjustable Rocker Arm Kit, Front Exhaust/Rear Intake (includes items 2, 5, 6) | 17300069 |
2 | Rocker arm, adjustable, front exhaust/rear intake | Not sold separately |
3 | Adjustable Rocker Arm Kit, Rear Exhaust/ Front Intake (includes items 4, 5, 6) | 17300070 |
4 | Rocker arm, adjustable, rear exhaust/front intake | Not sold separately |
5 | Lash adjuster screw | Not sold separately |
6 | Lash adjuster nut | Not sold separately |
Items mentioned in text, but not included in kit: | ||
A | Rocker arm fixed arm | |