FLHR WINDSHIELD KITS
J007182017-08-22
GENERAL
Kit Number
57981-97, 57994-94, 57995-96, 57767-00, 58163-02, 58731-02, 58796-02, 57807-04, 57668-10, 57400380, 57400381, 57400383
Models
For model fitment information, see the P&A retail catalog or the Parts and Accessories section of www.harley-davidson.com (English only).
Table 1. Models
Kits
Contents
57981-97
Low profile smoked windshield
57767-00
Low profile clear windshield
57994-94
Standard height clear windshield
57995-96
Tall clear windshield
58163-02
Road King wind deflector, dark, smoked
58731-02
Road King wind deflector, clear, international
58796-02
Road King wind deflector, dark smoked, 3 inches oversized
57807-04
Standard height clear windshield with flames
57668-10
Windshield, China
57400380
20" clear windshield with black braces
57400381
18" clear windshield with black braces
57400383
16" light tint windshield with black braces
NOTICE
Do not use windshield bags with flamed windshields. Damage to graphics will occur. (00393f)
Kit Contents
INSTALLATION
  1. Lower the windshield into position by carefully inserting the side brackets between the headlamp housing and the passing lamp supports until the bottom notches are seated on the lower grommets. Be sure that the notches on each bracket are firmly seated on a rubber grommet.
  2. Standing at the front of the motorcycle, gently push the top of the windshield toward the rear until the upper notches fully engage the upper grommets.
  3. Push down on the wireform latch springs so that they overhang the rubber grommets. If some adjustment is necessary, loosen the retaining bolts and rotate the latch springs into the proper position.
WARNING
Improper installation of accessories or loading of cargo can affect motorcycle stability and handling, which could result in death or serious injury. (00455b)
WARNING
Failure to provide adequate clearance between stationary and moving parts can cause loss of control, which could result in death or serious injury. (00378a)
NOTE
Inspect windshield upon completion of installation. Be sure windshield mounting does not restrict full left or full right movement of front fork assembly. If restriction does occur, adjust windshield as needed until proper clearance is obtained. Have experienced Harley-Davidson service personnel correct any problems before riding with this accessory installed.
NOTE
Check mounting hardware periodically. Never ride with loose mounts. A loose mounting causes extra stress on all other mounts, as well as the windshield itself, and could result in premature failure of components.
CARE AND CLEANING
NOTE
Sunlight reflections off of the inside curvature of a windshield can, at certain times of the day, cause extreme heat build-up on motorcycle instruments. Exercise care in parking. Park facing the sun, place an opaque object over the instruments, or adjust the windshield to avoid reflections.
NOTICE
Polycarbonate windscreens/windshields require proper attention and care to maintain. Failure to maintain polycarbonate properly can result in damage to the windscreen/windshield. (00483d)
NOTICE
Use only Harley-Davidson recommended products on Harley-Davidson windshields. Do not use harsh chemicals or rain sheeting products, which can cause windshield surface damage, such as dulling or hazing. (00231c)
Do not clean polycarbonate in hot sun or high temperature. Powdered, abrasive or alkaline cleanser will damage the windshield. Never scrape the windshield with a razor blade or other sharp instruments because permanent damage will result.
NOTE
Covering the windshield with a clean, wet cloth for about 15 minutes before washing will make dried bug removal easier.
Harley-Davidson Windshield Water Repellent Treatment Part Number 99841-01 is approved for use on Harley-Davidson polycarbonate windshields.
SERVICE PARTS
NOTE
Typical windshield shown. Actual windshield may vary
Figure 1. Service Parts: Service Parts: Wind Deflector
Table 2. Service Parts: Wind Deflector
Kits 57981-97, 57994-94, 57995-96, 57767-00, 57807-04, 57668-10
Item
Description (Quantity)
Part Number
Item
Description (Quantity)
Part Number
1
Windshield, clear, 2 inches oversize
58433-96
7
Inner horizontal brace
53431-94
Windshield, clear, standard
58193-94
8
Right bracket
58084-94
Windshield, clear, 4 inches undersized
57768-00
9
Left bracket
58088-94
Windshield, smoked, 4 inches undersized
58195-94
10
Spring latches (2)
38722-94
Windshield, clear with flames
57809-04
11
Panhead Torx screws (2)
2452
Windshield, China
57400005
12
Panhead Torx screws (11)
2921A
2
Outer, right, vertical brace
58406-75A
13
Plain washers (8)
6119
3
Outer, left, vertical brace
58408-75A
14
Acorn nuts (13)
7651
4
Outer vertical brace tape (2)
58417-77
Reference items:
5
Outer horizontal brace
58428-94
A
Rubber grommet
6
Horizontal brace tape (2)
58416-77A
Figure 2. Service Parts: Wind Deflector
Table 3. Service Parts: Wind Deflector
Kits 58163-02, 58731-02, 58796-02
Item
Description (Quantity)
Part Number
Item
Description (Quantity)
Part Number
1
Wind deflector, smoked
58906-02
8
Right bracket
58542-02
Wind deflector, clear, international
58908-02
9
Left bracket
58543-02
Wind deflector, smoked, 3 inch oversized
58799-02
10
Spring latches (2)
38722-94
2
Outer, right, vertical brace
58674-02
11
Panhead Torx screws (2)
2452
3
Outer, left, vertical brace
58677-02
12
Panhead Torx screws (11)
2921A
4
Outer vertical brace tape (2)
58664-02
13
Plain washers (8)
6119
5
Outer horizontal brace
58476-02
14
Acorn nuts (13)
7651
6
Horizontal brace tape (2)
58573-02
Reference items:
7
Inner horizontal brace
58462-02
A
Rubber grommet
Figure 3. Service Parts: Wind Deflector
Table 4. Service Parts: Wind Deflector
Kits 57400380, 57400381, 57400383
Item
Description (Quantity)
Part Number
Item
Description (Quantity)
Part Number
1
Wind deflector, clear, 20 inch
58193-94
8
Right bracket, black
57300188
Wind deflector, clear, 18 inch
58327-06
9
Left bracket, black
57300190
Wind deflector, lt smk, 16 inch
58195-94
10
Spring latches (2)
38722-94
2
Outer, right, vertical brace, black
57300187
11
Panhead Torx screws (2)
2452
3
Outer, left, vertical brace, black
57300189
12
Panhead Torx screws (11)
2921A
4
Outer vertical brace tape (2)
Not Sold Separately
13
Plain washers (8)
6119
5
Outer horizontal brace, black
57300191
14
Acorn nuts (13)
7651
6
Horizontal brace tape (2)
Not Sold Separately
Reference items:
7
Inner horizontal brace, black
57300192
A
Mounting Hardware Kit
58221-04