1. | See the service manual. Remove outer fairing. | |||||||||||||||
2. | See Figure 1. Remove the mirrors (1), flange nuts (3) and plastic backing plates (2) securing the mirrors to each side of the inner fairing. Retain all items. | |||||||||||||||
3. | Measure 25 mm (1 in) outboard (4) from the large mirror stud hole in the inner fairing, and make a mark. | |||||||||||||||
4. | Drill a 6 mm (¼ in) diameter hole through the inner fairing at the mark. | |||||||||||||||
5. | Repeat Steps 3 and 4 for opposite side. NOTE Make sure ambient temperature is at least 10 °C (50 °F) for proper adhesion of the mirror cover to the mirror. | |||||||||||||||
6. | Clean the back surface of the mirrors with the alcohol pad provided. Allow to dry completely. | |||||||||||||||
7. | Obtain the primer tube from the kit, and follow the instructions on the tube to activate the primer. When the primer is activated apply the primer to the back surface of one mirror. NOTE The Illuminated Chrome Mirror Covers are side-specific. The covers install with the wire harness exiting from the bottom. |
Figure 1. Mirror Cover Installation | ||||||||||||||
8. | Obtain the correct mirror cover from the kit. Rub the liners on the three pads on the back surface of the mirror cover to activate the adhesive. Then remove the liners. | |||||||||||||||
9. | Place the mirror cover over the back surface of the mirror and press into place for a minimum of 60 seconds. | |||||||||||||||
10. | Repeat Steps 7 through 9 for the remaining mirror and cover. | |||||||||||||||
11. | Position the mirror on the outer face of the inner fairing, with the rounded side of the mirror outboard. a. See Figure 1. Insert the mirror cover wire (7) through the drilled hole (4). b. Secure wiring grommet (6) in drilled hole. c. Insert the mirror post through the original mirror mounting hole. d. Install backing plate over mirror assembly. Make sure the locating pin is secured in the small hole of the backing plate. e. Install flange nut. Tighten to 2.3–3.4 N·m (20–30 in-lbs). f. Repeat steps for the opposite side. |
1 | Turn signal harness connector, female |
2 | Turn signal connector, male |
3 | Y-harness |
4 | Mirror cover connector |
Item | Description (Quantity) | Part Number |
---|---|---|
1 | Mirror cover, right | Not Sold Separately |
2 | Mirror cover, left | Not Sold Separately |
3 | Grommet (2) | Not Sold Separately |
4 | Terminal, pin, #20-22 AWG (6) | 72910-11 |
5 | Seal, pin (6) | 5118 |
6 | Housing, 4-way, pin, JAE (2) | 72908-11 |
7 | Y-harness (2) | 69200880 |
8 |
| 72908-11 |
9 |
| 72910-11 |
10 |
| 72907-11 |
11 |
| 72909-11 |
12 | Alcohol packet (not shown) | Not Sold Separately |
13 | Primer packet (not shown) | Not Sold Separately |